Author Topic: Measurement of Static Electricity Generated from Contact and Separation of Cloth  (Read 2965 times)

0 Members and 1 Guest are viewing this topic.

IJSER Content Writer

  • Sr. Member
  • ****
  • Posts: 327
  • Karma: +0/-1
    • View Profile
Author : Shoush K. A., Mohamed M. K., Zaini H. and Ali W. Y.
International Journal of Scientific & Engineering Research Volume 4, Issue 10, October-2013
ISSN 2229-5518
Download Full Paper : PDF

Abstract-Measurement of static electricity is of critical importance in assessing the proper electric properties of car seat covers and their suitability to be used in application to enhance the safety and stability of the driver. The present work aims to measure the static electric charge generated from the contact and separation of materials used as car seat covers and clothes. Different materials of car seat covers and clothes were tested to measure the voltage generated from electric static charge .It was found that voltage generated by the contact and separation of the tested upholstery materials of car seat covers against the materials of clothes showed great variance according to the type of the materials. The materials tested showed different trend with increasing load. The contact and separation of the tested against polyamide textiles generated negative voltage, where voltage increased down to minimum then decreased with increasing load. The behaviour can be interpreted on the fact that as the load increased the two rubbed surfaces, charged by free electrons, easily exchanged the electrons of dissimilar charges where the resultant became relatively lower voltage. High density polyethylene displayed relatively lower voltage than cotton and polyamide textiles, while polypropylene textiles displayed relatively higher voltage than that shown for high density polyethylene. The variance of the voltage with load was much pronounced. Voltage generated from polyester textiles showed reasonable values. Remarkable voltage increase was observed for contacting synthetic rubber. This observation can limit the application of synthetic rubber in tailoring clothes.Based on the experimental results the materials of car seat covers can be classified according to their electric properties. Materials of high static electricity can be avoided and new materials of low static electricity can be recommended.

Keywords-Electric static charge, voltage, cotton, polyester, textiles, upholstery materials, car seat covers, triboelectrification


he wide use of polymer fibres in textiles necessitates to study their electrification when they rubbing other surfaces. The electric static charge generated from the friction of different polymeric textiles sliding against cotton textiles, which used as a reference material, was discussed, [1]. Experiments were carried out to measure the electric static charge generated from the friction of different polymeric textiles sliding against cotton under varying sliding distance and velocity as well the load. It was found that increase of cotton content decreased the generated voltage. Besides, as the load increased voltage generated from rubbing of 100 % spun polyester specimens increased. Besides, mixing polyester with rayon (viscose) showed the same behavior of mixing it with cotton. Generally, increasing velocity increased the voltage. The voltage increase with increasing velocity may be attributed to the increase of the mobility of the free electrons to one of the rubbed surfaces. The fineness of the fibres much influences the movement of the free electrons. The electrostatic charge generated from the friction of polytetrafluoroethylene (PTFE) textiles was tested to propose developed textile materials with low or neutral electrostatic charge which can be used for industrial application especially as textile materials, [2]. Test specimens of composites containing PTFE and different types of common textile fibers such as cotton, wool and nylon, in a percentage up to 50 vol. % were prepared and tested by sliding under different loads against house and car padding textiles. Ultra surface DC Voltmeter was used to measure the electrostatic charge of the tested textile composites. The results showed that addition of wool, cotton and nylon fibers remarkably decreases the electrostatic discharge and consequently the proposed composites will become environmentally safe textile materials.
Research on electrostatic discharge (ESD) ignition hazards of textiles is important for the safety of astronauts. The likelihood of ESD ignitions depends on the environment and different models used to simulate ESD events, [3]. Materials can be assessed for risks from static electricity by measurement of charge decay and by measurement of capacitance loading, [4]. Tribology is the science and technology of two interacting surfaces in relative motion and of related subjects and practices. The popular equivalent is friction, wear, and lubrication, [5]. Tribological behavior of polymers is reviewed since the mid-20th century to the present day. Surface energy of different coatings is determined with contact adhesion meter. Adhesion and deformation components of friction were discussed. It was shown how load, sliding velocity, and temperature affect friction. Different modes of wear of polymers and friction transfer were considered, [6]. The ability to engineer a product痴 tactile character to produce favorable sensory perceptions has the potential to revolutionize product design. Another major consideration is the potential for products to produce friction-induced injuries to skin such as blistering, [7, 8]. Sports activities may cause different types of injuries induced by friction between the skin and sport textiles. Focusing on runners who are often bothered with blisters, the textile貿oot skin interface was studied in order to measure and predict friction. The characteristics of mechanical contacts between foot, sock and shoe during running were determined. It was found that textiles with conductive threads did not give ignitions provided they were adequately earthed, [9]. When isolated, all textiles were capable of causing ignitions regardless of the anti-static strategy employed.

Read More: Click here...